Product ID:50010540 TECTYL 502C
MSDS Date:04/12/1991
FSC:6850
NIIN:00F031392
MSDS Number: BSNHC

VALVOLINE OIL CO

3499 DABNEY DR
LEXINGTON, KY 40512
US

Emergency Phone: 606-264-7000

Info Phone: 606-264-7000

Cage: 72527

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

ISOPARAFFINIC HYDROCARBONS (NAPHTHA PETROLEUM),

CAS: 64742-48-9

Fraction By Weight: 25-40%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

LIGHT NAPHTHALIC DISTILLATE, HYDROTREATED LIGHT NAPHTHENIC

CAS: 64742-53-6

RTECS: PY8036000

Fraction By Weight: 10-25%

OSHA PEL 5 MG/CUM

ACGIH TLV: 5 MG/CUM

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: SEVERE IRRITATION. SKIN:
PROLONGED/REPEATED CONTACT MAY CAUSE MODERATE
IRRITATION/DEFATTING/DERMATITIS. INHALATION: VAPORS MAY CAUSE NASAL
& RESPIRATORY IRRITATION/CNS EFFECTS/DEATH. INGESTION:
GASTROINTESTINAL IRRITATION. ASPIRATIONINTO LUNGS MAY CAUSE
CHEMICAL PNEUMONITIS, WHICH CAN BE FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: REDNESS, TEARING, BLURRED VISION.
INHALATION: DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE,
POSSIBLE UNCONSCIOUSNESS. INGESTION: NAUSEA, VOMITING, & DIARRHEA.

First Aid:SKIN: THOROUGHLY WASH EXPOSED AREA W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
EYES: FLUSH W/LARGE AMOUNTS OF WATER. INGESTION: DON'T INDUCE
VOMITING. ASP IRATION HAZARD. KEEP WARM/QUIET. NEVER GIVE ANYTHING
BY MOUTH IF UNCONSCIOUS. INHALATION: REMOVE TO FRESH AIR. KEEP
WARM/QUIET. GIVE CPR/OXYGEN IF NECESSARY. OBTAIN MEDICAL ATTENTION
IN ALL CASES.

Flash Point:>100F/37.8C
Lower Limits:0.6%
Extinguishing Media:REGULAR FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WATER/FOAM MAY CAUSE FROTHING, WHICH CAN BE
VIOLENT IF SPRAYED INTO CONTAINERS OF HOT/BURNING LIQUID. WEAR SCBA
W/FULL FACEPIECE OPERATED IN PRESSURE DAMAND.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR/TRAVEL ALONG
GROUND/IGNITE BY IGNITION SOURCE. COMBUSTIBLE.

Spill Release Procedures:SMALL: ABSORB LIQUID ON
PAPER/VERMICULITE/FLOOR ABSORBENT. LARGE: REMOVE IGNITION SOURCE.
WEAR PROTECTIVE EQUIPMENT/EVACUATE AREA. STOP AT SOURCE/DIKE TO
PREVENT SPREADING/PUMP LIQUID TO SALVAGE TANK. TAKE UP REMAINING &
SHOVEL INTO CONTAINERS.

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT
RESIDUES, ALL HAZARD PRECAUTIONS MUST BE OBSERVED.
Other Precautions:NEVER USE WELDING/CUTTING TORCH ON/NEAR DRUM (EVEN
EMPTY) BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN IGNITE EXPLOSIVELY.
ALL 5 GALLON PAILS/LARGER METAL CONTAINERS (TANK CARS/TRUCKS)
SHOULD BE GROUNDED/B ONDED WHEN LIQUID TRANSFERRED.(SEE SUPP)

Respiratory Protection:IF EXCEEDED TLVS, WEAR NIOSH/MSHA APPROVED AIR
SUPPLIED RESPIRATOR IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL.
ENGINEERING OR ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO
REDUCE EXPOSURE.
Ventilation:SUFFICIENT MECHANICAL (GENERAL/LOCAL EXHAUST) TO MAINTAIN
EXPOSURE BELOW TLVS.
Protective Gloves:NEOPRENE OR NITRILE (RESISTANT)
Eye Protection:CHEMICAL SPLASH GOGGLES/SAFETY GLASSES
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS & LEGS
Work Hygienic Practices:PRACTICE GOOD HYGIENE.
Supplemental Safety and Health
PRECAUTIONS CONT'D: KEEP AWAY FROM HEAT & OPEN FLAME. USE OR STORE ONLY
W/ADEQUATE VENTILATION. MAINTAIN AMBIENT AIR CONCENTRATIONS BELOW
PERMISSIBLE EXPOSURE LIMITS. AVOID CONTACT W/EYES & PROLONGED/
REPEATED CONTACT W/SKIN. DON'T TRANSFERTO UNLABELED CONTAINERS. FOR
INDUSTRIAL USE ONLY.

Boiling Pt:B.P. Text:302F
Vapor Pres:2
Vapor Density:>1
Spec Gravity:0.871
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIQUID
Percent Volatiles by Volume:25-40

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:IGNITION SOURCES
Hazardous Decomposition Products:CO2, CO, VARIOUS HYDROCARBONS, SULFUR
COMPOUNDS

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. COMBUSTIBLE. PREVENT RUN-OFF TO SEWERS,
STREAMS, OR OTHER BODIES OF WATER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.